文献类型：期刊文献

中文题名：麦草化学机械浆漂白废液的研究

英文题名：A study on the bleaching wastewater of straw chemical-mechanical pulp

作者：李红斌[1,2] 房桂干[1] 耿光林[2] 方辉[2]

第一作者：李红斌

机构：[1]中国林业科学研究院林产化学工业研究所;[2]山东晨鸣纸业集团股份有限公司技术中心

年份：2010

期号：5

起止页码：67-70

中文期刊名：中华纸业

外文期刊名：China Pulp & Paper Industry

收录：北大核心:【北大核心2008】；

语种：中文

中文关键词：麦草化学机械浆;过氧乙酸;硼氢化钠;漂白废液

分类号：X793;TS749.2

摘要：介绍了麦草化学机械浆使用过氧化氢/过氧乙酸和过氧化氢/硼氢化钠组合工艺分别漂白至72.83%ISO,73.98%ISO的高白度条件下,过氧乙酸和硼氢化钠漂白废液的污染负荷以及废液的成分。研究结果表明:麦草化学机械浆P1P2B漂白工艺三段漂白废水BOD与COD总发生量分别为149.06kg/t浆和384.24kg/t浆,均低于PaP1P2漂白工艺三段漂白废水BOD与COD总发生量,BOD相比降低了15.84%,COD降低了19.26%;两种漂白废液的主要污染物质成分构成较为相近,均含有芳香族化合物和脂肪族化合物,但是Pa漂白废液中酯类有机物和4,4′-二羟基二苯丙烷的相对含量明显高于NaBH4漂白废液的相对含量。
The pollutant load and composition of two kinds of bleaching wastewater bleached by peracetic acid combined with hydrogen peroxide with brightness 72.83%ISO and sodium borohydride combined with hydrogen peroxide with brightness 73.9%ISO were introduced. The results show that the total amount of BOD and COD of P1P2B three-stage bleaching wastewater of straw chemical-mechanical pulp were 149.06kg/t and 384.24kg/t respectively, both lower than the amount of PaP1P2 three-stage bleaching wastewater with the reduction of BOD 15.84% and COD 19.26%. Aromatic compounds and aliphatic compounds can be found in both two kinds of bleaching wastewater, but the content of esters organic compounds and 4,4＇-（1-methylethylidene） bis-organicas in Pa bleaching wastewater is much higher than that in NaBH4 bleaching wastewater.