文献类型：期刊文献

中文题名：十一烯酸基乳化剂制备及应用研究

英文题名：Preparation and Application of Emulsifier Based on Undecylenic Acid

作者：张永贺[1,2] 付高位[1,2] 金立维[1]

第一作者：张永贺

机构：[1]中国林业科学研究院林产化学工业研究所/生物质化学利用国家工程实验室/国家林业和草原局林产化学工程重点实验室/江苏省生物质能源与材料重点实验室,江苏南京210042;[2]南京林业大学江苏省林业资源高效加工利用协同创新中心,江苏南京210037

年份：2019

卷号：53

期号：6

起止页码：22-26

中文期刊名：生物质化学工程

外文期刊名：Biomass Chemical Engineering

收录：北大核心:【北大核心2017】；

基金：国家重点研发计划资助项目(2017YFE0106800)

语种：中文

中文关键词：乳化剂;十一烯酸;马来酸酐;十二醇

外文关键词：emulsifier;undecylenic acid;maleic anhydride;dodecanol

分类号：TQ35;TQ325

摘要：利用十二醇(DA)与十一烯酸(UA)/马来酸酐(MAH)共聚物通过酯化反应制备了UMA-DA聚合物,并将聚合物作为乳化剂用于UA与甲基丙烯酸甲酯(MMA)的乳液聚合中。FT-IR分析表明:DA中的羟基与UMA共聚物中的酸酐发生了反应。1H NMR结果表明:在δ3.2~3.4处有明显的—O—CH2—质子信号,表明成功制备了UMA-DA共聚物。通过表面张力法对UMA皂化物的临界胶束浓度(CMC)值进行了测定,UMA-DA的CMC值为9.6 g/L,此时表面张力γCMC为23.04 mN/m,UMA-DA的γCMC值要远低于纯水(71.97 mN/m)。在乳液聚合时,随UMA-DA用量的不断增加,乳液粒径和粒径分散系数(PDI)增大,凝胶率逐渐减小。当自制乳化剂UMA-DA用量为总单体的10%且UA与MMA质量比10∶90时乳液较为稳定,总单体转化率为98.1%。
Undecylenic acid/maleic anhydride-dodecanol(UMA-DA)polymer was prepared by esterification reaction using dodecanol(DA)and undecylenic acid(UA)/maleic anhydride(MAH)as copolymer.The polymer is used as an emulsifier in the emulsion polymerization of UA and methyl methacrylate(MMA).FT-IR analysis showed that the self-made undecylenic acid/maleic anhydride(UMA)copolymer acted with DA by esterification of an acid anhydride with a hydroxyl group.The proton signal atδ3.2-3.4 of—O—CH2—in 1 H NMR show that UMA-DA copolymer was prepared successfully.The critical micelle concentration(CMC)value of UMA saponification was determined by surface tension method.The CMC value of UMA-DA was 9.6 g/L,and the surface tensionγCMC was 23.04 mN/m.TheγCMC value of UMA-DA is much lower than that of pure water(71.97 mN/m).The particle size and particle size distribution index(PDI)increased,butthe gel rate gradually decreasedwith the increase of UMA-DA dosage in emulsion polymerization.The emulsion is relatively stable,and the total monomer conversion rate reaches 98.1%when the amount of the self-made emulsifier UMA-DA is 10%of the total monomer and the ratio of UA to MMA is 10∶90.