文献类型：期刊文献

中文题名：银杏叶总黄酮的负压沸腾提取工艺

英文题名：Optimization of Decompressing Ebullition Extraction of Total flavonoids from Ginkgo Leaves

作者：周昊[1] 王成章[1] 叶建中[1] 陈虹霞[1] 陶冉[1] 张宇思[1]

第一作者：周昊

机构：[1]中国林业科学研究院林产化学工业研究所

年份：2015

卷号：43

期号：6

起止页码：128-132

中文期刊名：东北林业大学学报

外文期刊名：Journal of Northeast Forestry University

收录：CSTPCD;;北大核心:【北大核心2014】；CSCD:【CSCD_E2015_2016】；

基金："十二五"国家科技支撑计划资助(2012BAD21B04);江苏省林业三新工程项目(LYSX[2014]15);江苏省产学研联合创新基金前瞻性联合研究项目(BY2012042)

语种：中文

中文关键词：银杏叶;总黄酮;负压沸腾提取;响应曲面法;工艺优化

外文关键词：Ginkgo leaves;Flavonoids;Decompressing ebullition extraction;Response surface methodology;Technology optimization

分类号：S715.3

摘要：以银杏叶为原料,在单因素试验的基础上,采用响应面分析法对影响负压沸腾提取银杏叶总黄酮得率的主要因素(提取压力、V(60%乙醇)∶m(银杏叶干粉)和提取时间)进行优化,建立了影响因素与总黄酮之间的函数关系。结果表明:10 g银杏叶干粉,负压提取最佳工艺条件为提取压力-0.08 MPa,提取时间70 min,提取温度50℃,V(60%乙醇)∶m(银杏叶干粉)=10 m L∶1 g,提取2次,银杏叶总黄酮提取率为93.55%。与传统提取法相比(提取率为81.69%),负压沸腾提取温度降低了30℃,提取时间减少了42%。
We used response surface methodology （ RSM ） to optimize decompressing ebullition extraction for total flavonoids from Ginkgo leaves by single-factor experiment , and determined the main factors extraction pressure , ratio of liquor to ma-terial and extraction time .We established the relationship between influencing factors and response values .The optimum extraction conditions were under the extraction pressure of -0.08 MPa, the extraction time of 70 min, the extracting tem-perature of 50℃, and the maximal yield of total flavonoids of 93.55%.Compared with the traditional extraction method , the temperature was cut down by 30℃, and the extraction time was reduced by 42%.